ACC Cabin Filter (BOSCH Microfilter), Some cars require 2
Air Filter (Mann, Mahle, BOSCH)
Spark Plugs (BOSCH, NTK.....)
Brake Fluid (ATE super Blue)
Bentley BMW Service Manual
BMW Inspection I
The BMW Inspection 1 Service is the smaller of the two
inspection services recommended by BMW. It includes basically all of the
items that assures safety and full functionality of your vehicle. Other makes
and models can also utilize this maintenance program to ensure a pleasant drive
and ownership (But make sure you mechanic says it is OK first). Inspection 1
could cost in the range of $200+ to $300+ depending on who you go to and also if
you have any repairs. (Repair cost are not included in the inspection cost) So
be prepared to spend more!. If your mechanical skills are high, just
DO-It-Yourself! The items that are generally checked are listed below. If you
are performing the inspection yourself, We carry most of the BMW parts you need
to complete the inspection and replacement of BMW parts. Click here for the Online
BMW Parts Catalog. Don't forget to purchase the BMW
service/oil change reset tool.
Undercarriage
Change engine oil and filter oil while engine is at
normal operation temperature.
Check transmission for leaks.
Check rear axle for leaks.
Visually check fuel tank, lines, and connections for
leaks.
Check condition, position, and mounting of exhaust
system. Examine for leaks.
Check power steering system for leaks.
Check overall thickness of front and rear disc brake
pads.
Examine brake disc surfaces.
Clean brake pad contact points in calipers.
Grease wheel center hubs.
Check steering for absence of play, condition of
suspension track rods, front axle joints, steering linkage, and joint
disc.
Check front control arm bushing for wear.
Check brake and clutch system connectors and lines
for leaks, damage, and incorrect positioning.
Check for free movement of the parking brake cables.
Adjust parking brake if necessary.
Check all tire pressures (including spare). Correct
if necessary.
Check condition of tires (outer surfaces
(left/right)), tread wear and pattern; In case of uneven tread wear
readjust wheel alignment if required.
Engine Compartment
Read out diagnostic system
Check engine cooling system/heater hose connections
for leaks.
Check coolant level and antifreeze protection level;
add coolant if necessary.
Check level of brake and clutch fluid in reservoir;
add fluid if required.
Check windshield washer fluid level and antifreeze
protection. Fill up and/or correct if necessary.
Check air conditioner for operation.
Reset Service Indicator.
Body/Electrical Equipment
Check battery electrolyte level and add distilled
water if required.
Visually examine the SRS airbag units for torn cover,
obvious damage or attachment of decals, decorations, or accessories.
Final Inspection
Road test with check of brakes, suspension, steering,
clutch/manual transmission or automatic transmission
Inspection II
The Inspection 2 Service is the larger of the two Inspection
Services and basically includes all of the items performed on the Inspection I
Service along with some extras like differential oil change; fuel filter and air
filter replacements; Replacement of spark plugs. Inspection 2 generally runs
around $500+ to $800+. Below are the items that are normally performed. If
you are performing the inspection yourself, We carry most of the BMW parts you
need to complete the inspection and replacement of BMW parts. Click here for the
Online BMW Parts Catalog. Don't forget to purchase the
BMW service/oil change reset
tool.
Undercarriage
Change engine oil and filter oil while engine is at
normal operation temperature.
Check transmission for leaks.
Check rear axle for leaks.
Visually check fuel tank, lines, and connections for
leaks.
Check condition, position, and mounting of exhaust
system. Examine for leaks.
Check power steering system for leaks.
Check overall thickness of front and rear disc brake
pads.
Examine brake disc surfaces.
Clean brake pad contact points in calipers.
Grease wheel center hubs.
Check steering for absence of play, condition of
suspension track rods, front axle joints, steering linkage, and joint
disc.
Check front control arm bushing for wear.
Check brake and clutch system connectors and lines
for leaks, damage, and incorrect positioning.
Check for free movement of the parking brake cables.
Adjust parking brake if necessary.
Check all tire pressures (including spare). Correct
if necessary.
Check condition of tires (outer surfaces
(left/right)), tread wear and pattern; In case of uneven tread wear
readjust wheel alignment if required.
Check thickness of parking brake linings.
Half-shafts; check for leaks at flexible boots.
Inspect entire body according to terms of rust
prevention limited warranty.
Engine Compartment
Read out diagnostic system
Check engine cooling system/heater hose connections
for leaks.
Check coolant level and antifreeze protection level;
add coolant if necessary.
Check level of brake and clutch fluid in reservoir;
add fluid if required.
Check windshield washer fluid level and antifreeze
protection. Fill up and/or correct if necessary.
Check air conditioner for operation.
Reset Service Indicator.
Replace spark plugs.
Replace intake air cleaner element.
Body/Electrical Equipment
Check battery electrolyte level and add distilled
water if required.
Visually examine the SRS airbag units for torn cover,
obvious damage or attachment of decals, decorations, or accessories.
Final Inspection
Road test with check of brakes, suspension, steering,
clutch/manual transmission or automatic transmission
These are the recommended interval for models years from
1986 through 1998 models, more frequent inspections are essential if driven in
extreme conditions:
5,000 miles - intermediate oil service (O/F)
10,000 miles - Oil and Safety Service (O/S)
15,000 miles - intermediate oil service (O/F)
20,000 miles - BMW Inspection I (I/1)
25,000 miles - intermediate oil service (O/F)
30,000 miles - Oil and Safety Service (O/S)
35,000 miles - intermediate oil service (O/F)
40,000 miles - BMW Inspection II (I/2)
45,000 miles - intermediate oil service (O/F)
50,000 miles - Oil and Safety Service (O/S)
55,000 miles - intermediate oil service (O/F)
60,000 miles - BMW Inspection I (I/1)
65,000 miles - intermediate oil service (O/F)
70,000 miles - Oil and Safety Service (O/S)
75,000 miles - intermediate oil service (O/F)
80,000 miles - BMW Inspection II (I/2)
85,000 miles - intermediate oil service (O/F)
90,000 miles - Oil and Safety Service (O/S)
95,000 miles - intermediate oil service (O/F)
For 1999 and later models, the recommended service/inspection
intervals are as follows:
*Disclaimer: The articled presented/submitted on
Bimmerzone.com are for the sole purpose of learning and basic information.
In no way that information provided on Bimmerzone.com be considered
professional advice and Bimmerzone.com will not be held responsible for any
consequences resulting directly or indirectly from reading these articles.
In our articles we mention about brand names and stores, these are for
education, comparison and information purposes only. We do not
specifically endorse any companies.
Part Number Search
